BCWA pipeline repair reaches crucial "prover" stage

By Ted Hayes
Posted 10/18/19

Contractors repairing the Bristol County Water Authority’s leaky East Bay Pipeline on Friday entered the most crucial phase of the $4.6 million project so far — making sure they can …

This item is available in full to subscribers.

Please log in to continue

Log in

Register to post events


If you'd like to post an event to our calendar, you can create a free account by clicking here.

Note that free accounts do not have access to our subscriber-only content.

Day pass subscribers

Are you a day pass subscriber who needs to log in? Click here to continue.


BCWA pipeline repair reaches crucial "prover" stage

Posted

Contractors repairing the Bristol County Water Authority’s leaky East Bay Pipeline on Friday entered the most crucial phase of the $4.6 million project so far — making sure they can actually insert a liner all the way through the pipeline under the Providence River.

On Friday, crews threaded a bit through the leaking pipeline from Providence, where crews in East Providence retrieved it and hooked it to  a 40-foot PVC “prover" liner. From there, workers began the delicate task of pulling that short liner back through to Providence. The prover is the same diameter and material as the PVC tubing that will eventually line the pipeline, and its job is to make sure there are no snags or obstructions inside  that will impede the permanent liner’s path as it is pulled through.

BCWA Executive Director Pamela Marchand said Friday that she didn’t expect the prover to make it all the way through by the end of the workday Friday. But she said that if all goes well, it will reach the other end in Providence Monday.

If the prover shows the line is sound and obstruction-free, work to pull 10 450-foot sections of PVC pipeline through, welding the ends together as they go, could commence early next week.

“Keeping fingers crossed!,” she wrote in an e-mail.

The pipeline starts at the Port of Providence and terminates adjacent to land owned by the Silver Spring Golf Club in East Providence. At either end of its route the line takes an approximately 45-degree sharp turn upward. To get to the point where the prover could be installed, workers had to remove each “elbow” at the two 45-degree bends, so the semi-rigid PVC would have a relatively flat route to travel across and under the river. Getting it past those 45-degree bends would have been impossible, Ms. Marchand said.

Once the PVC liner is inserted all the way through, those 45-degree bends will be re-installed, the pipeline pressure tested and, if good, be brought back into service. Ms. Marchand said the work could take a month or more to complete from this point.

2024 by East Bay Media Group

Barrington · Bristol · East Providence · Little Compton · Portsmouth · Tiverton · Warren · Westport
Meet our staff
MIKE REGO

Mike Rego has worked at East Bay Newspapers since 2001, helping the company launch The Westport Shorelines. He soon after became a Sports Editor, spending the next 10-plus years in that role before taking over as editor of The East Providence Post in February of 2012. To contact Mike about The Post or to submit information, suggest story ideas or photo opportunities, etc. in East Providence, email mrego@eastbaymediagroup.com.